Authors : Chinwah, K. B.; Iregbu, P. O.; Jaja Zina.

Volume/Issue : Volume 11 - 2026, Issue 4 - April

Google Scholar : https://tinyurl.com/y2ac8jdj

Scribd : https://tinyurl.com/8ac2as6p

DOI : https://doi.org/10.38124/ijisrt/26apr767

Note : A published paper may take 4-5 working days from the publication date to appear in PlumX Metrics, Semantic Scholar, and ResearchGate.

Abstract : Adsorption of engine oil using chemically activated chicken feathers was investigated with the aim of evaluating the efficiency, kinetics, and isotherm behaviour. Batch adsorption experiments were conducted using varying contact times (10–50 minutes) and adsorbent dosages (10 g and 20 g). The adsorption performance was evaluated based on percentage of adsorption capacity, while equilibrium data were analysed using Langmuir, Freundlich, and Temkin isotherm models. Results showed that adsorption efficiency increased with both contact time and adsorbent dosage. At 10 g dosage, efficiency increased from 44% to 76%, while at 20 g dosage, efficiency rose from 56% to a maximum of 98% at 50 minutes, indicating that higher adsorbent mass enhances oil removal due to increased availability of active sites. Isotherm analysis revealed that the Langmuir model provided the best fit (R² = 0.9048), suggesting monolayer adsorption on a relatively homogeneous surface with a maximum adsorption capacity (Qₘₐₓ) of 138.888 mg/g. The Temkin model showed moderate agreement (R² = 0.7064), indicating decreasing adsorption heat with surface coverage, while the Freundlich model exhibited poor fit (R² = 0.5123), suggesting that multilayer adsorption was not dominant. The results demonstrate that adsorption is primarily governed by physisorption mechanisms involving hydrophobic interactions and surface entrapment within the keratin structure of the feathers. Increased dosage significantly improved performance, while contact time influenced the transition from rapid surface adsorption to diffusion-controlled uptake. This study demonstrates that chemically activated chicken feathers are an effective, sustainable, and low-cost adsorbent for engine oil removal, exhibiting high adsorption efficiency and strong conformity to the Langmuir isotherm, highlighting their potential application in wastewater treatment and oil pollution remediation.

Keywords : Chicken Feather; Engine Oil; Adsorption Isotherm; Kinetics; Langmuir Model; Oil Remediation.

References :

1. M. Fingas, The Basics of Oil Spill Cleanup. Boca Raton, FL, USA: CRC Press, 2011.
2. R. M. Atlas and T. C. Hazen, “Oil biodegradation and bioremediation: A tale of the two worst spills in US history,” Environ. Sci. Technol., vol. 45, no. 16, pp. 6709–6715, 2011.
3. W. M. El-Sayed, D. A. El-Setouhy, and A. S. Al-Amre, “Biosorption of waste engine oil from aqueous solutions by some aquatic plants,” Int. J. Environ. Sci. Technol., vol. 12, no. 11, pp. 3505–3514, 2015.
4. M. O. Adebajo, R. L. Frost, J. T. Kloprogge, O. Carmody, and S. Kokot, “Porous materials for oil spill cleanup: A review of synthesis and applications,” J. Porous Mater., vol. 10, no. 4, pp. 273–290, 2003.
5. M. A. Hubbe, O. J. Rojas, M. Fingas, and B. S. Gupta, “Cellulosic substrates for removal of pollutants from aqueous systems: A review. 3. Spilled oil and hydrophobic compounds,” BioResources, vol. 8, no. 2, pp. 3057–3102, 2013.
6. T. Tesfaye, B. Sithole, D. Ramjugernath, and V. Chunilall, “Valorisation of chicken feathers: A biopolymer resource for sustainable applications,” Clean Technol. Environ. Policy, vol. 19, no. 11, pp. 2541–2561, 2017.
7. J. R. Barone and W. F. Schmidt, “Polyethylene reinforced with short keratin fibers from residues of the poultry industry,” Compos. Sci. Technol., vol. 66, no. 11–12, pp. 1618–1624, 2006.
8. N. Reddy and Y. Yang, “Structure and properties of chicken feathers and feather-based composites,” J. Polym. Environ., vol. 15, no. 2, pp. 81–87, 2007.
9. United Nations Environment Programme (UNEP), “Towards a green economy: Pathways to sustainable development and poverty eradication,” UNEP, Nairobi, Kenya, 2011.
10. K. Dolinar et al., “Composite materials based on waste chicken feather fibers for oil-spill management,” J. Nat. Fibers, vol. 21, no. 1, p. 2346803, 2024.
11. J. Wang and X. Guo, “Rethinking of the intraparticle diffusion adsorption kinetics model: Interpretation, solving methods and applications,” Chemosphere, vol. 309, pt. 2, p. 136732, 2022.
12. A. A. Mohammed, T. J. Al-Musawi, S. A. Lateef, A. M. Al-Ma’abreh, and A. Hamdi, “Simultaneous adsorption of tetracycline and doxycycline antibiotics by activated sludge-based biochar derived at different pyrolysis temperatures,” Arabian J. Chem., vol. 16, no. 3, p. 104541, 2023.
13. H. I. Kelle, A. N. Eboatu, et al., “Waste chicken feathers as sorbents for hydrocarbon and non-hydrocarbon spills,” Rivers State Univ. J. Network (RSUJNET), vol. 4, no. 3, pp. 6–15, 2022.
14. T. R. Annunciado, T. H. D. Sydenstricker, and S. C. Amico, “Experimental investigation of various extruded marine and agro-waste fibres for oil spill cleanup,” Mar. Pollut. Bull., vol. 50, no. 11, pp. 1340–1346, 2005.
15. C. I. Egwuatu, E. G. Amadi, K. O. Iwuozor, M. C. Udeagbala, E. C. Emenike, and A. G. Adeniyi, “Improving oil sorption efficiency through acetylation of chicken feathers: Process and kinetic insights,” Chemistry Africa, 2025.
16. J. Wang and X. Guo, “Adsorption isotherm models: Classification, physical meaning, application and solving method,” Chemosphere, vol. 258, p. 127279, 2020.
17. A. O. Dada, A. P. Olalekan, A. M. Olatunya, and O. Dada, “Langmuir, Freundlich, Temkin and Dubinin–Radushkevich isotherms studies of equilibrium sorption of Zn²⁺ unto phosphoric acid modified rice husk,” IOSR J. Appl. Chem., vol. 3, no. 1, pp. 38–45, 2012.
18. S. M. R. Razavi, S. Shirazian, and M. Nazemian, “Investigation of CO₂ removal from gas mixtures in porous membranes: A computational study using response surface methodology,” Arabian J. Chem., vol. 7, no. 6, pp. 1103–1113, 2014.
19. M. A. Al-Ghouti and D. A. Da’ana, “Guidelines for the use and interpretation of adsorption isotherm models: A review,” J. Hazard. Mater., vol. 393, p. 122383, 2020.
20. H. A. Chima et al., “Determination of the viability of chicken feather as oil spill clean-up sorbent for Engine Oil and its lower fractions,” J. Appl. Sci. Environ. Manage., vol. 22, no. 3, pp. 395–400, 2018.
21. O. Agboola and N. U. Benson, “Physisorption and chemisorption mechanisms influencing micro(nano)plastics–organic chemical contaminants interactions: A review,” Front. Environ. Sci., vol. 9, p. 727054, 2021.
22. S. Kalam, S. A. Abu-Khamsin, M. S. Kamal, and S. Patil, “Surfactant adsorption isotherms: A review,” ACS Omega, vol. 6, no. 48, pp. 32342–32348, 2021.
23. H. N. Tran, S. J. You, A. Hosseini-Bandegharaei, and H. P. Chao, “Mistakes and inconsistencies regarding adsorption of contaminants from aqueous solutions: A critical review,” Water Res., vol. 120, pp. 88–116, 2017.